saab documents

Workshop manual

Saab 900 Service Manual 3:2: Electrical System, System Diagrams, Operation and Fault-Tracing M1987–88

pages 21–30 of 238 (ocr, may contain errors)

Page 21

Earth connections 31

Components connected

Earthing point 7 is located below the radiator, on the
right-hand side of the radiator cross-member. The
following components are connected (by means of
screw terminals) to this earthing point. Some of the
components listed below are fitted only to cars of
certain versions or for certain markets.

Negative distribution terminal 158 in the electrical
distribution box is also connected to earthing point
Ts

Connections marked with "A” apply to cars without
integrated bumpers.

411 Headlamp full beam
12 Headlamp dipped beam
13 Parking lights
26 Time-delay relay for the radiator fan
28 Direction indicator lamp, right-hand front
37 Radiator fan motor (across 2-pole connec-
tor 59 at the radiator)
63 Washer motor
66 Headlamp wiper motor (across 3-pole con-
nector 57 in the engine compartment at the
corresponding motor)
85 Extra fog lamps
118 Corner lights
119 Side reversing light (RH)
130 Coolant temperature switch
138 Engine speed relay (Turbo with manual gear-
box only)
158 Negative distribution terminal
172 Radiator fan for the AC (across 2-pole con-
nector 59 at the radiator fan motor)
179 Solenoid valve for the APC system
234 Side marker lights (RH)

Cars with 8-valve engine for the U.S.A., Canada and
Japan

104 Hot start relay
105 Engine speed relay
106 Time-delay relay

Saab 900

Page 22

32 =~ Earth connections

Earthing point 9
191 SV 0.75 Ls sy 46
SY 101 (US, CA, JP, ME, FE, AU)
262A
SV 1.5
262 SV.25 oy 262 SV. 25 103
1890 SV _1.0 14, 30, 32 (LHS)
27 (LHR)
189E SV 1.0 14, 30, 32 (RHS)
28 (RHR)
US, CA

109

2A SV_25 eS 2A SV 2.5 an Sv. 0.78 144, 30/33 (RHS)

2-D, 4-D
189 SV 1.0 14, 14, 30, 30/33, 32 (LHS)
a (LHR)
189
SV 1.5
14, 14, 30, 30/33, 32 (RHS)
28 (RHR)
/779

Saab 900

Page 23

Earth connections 33

r) Components connected

Earthing point 9 is located under the spare wheel
hatch in the luggage compartment, at the extreme
rear on the centre member. The following compo-
nents are connected (by means of screw terminals) to
this earthing point. Some of the components listed
below are fitted only to cars of certain versions or for
certain markets. =

46 Fuel level transmitter (across 3-pole con-
nector 57, under the luggage compartment
floor, beside the transmitter)

101 Fuel feed pump (across 2-pole connector 59
under the luggage compartment floor)

103 Fuel pump (across 2-pole connector 59 un-
der the luggage compartment floor)

177 Control unit for the APC system

F 3-D, 5-D
The tailgate lighting is earthed to the tailgate which,
in turn, is earthed to earthing point 9 across cable
211A SV 2.5 (across 3-pole connector 57 in the
/ luggage compartment, at the left-hand air outlet).

14 Rear lights

15 Number plate illumination

27 Direction indicator lamps, left-hand

28 Direction indicator lamps, right-hand

30 Brake lamps

32 Reversing lamps

33 Rear fog lights

109 High-level brake light (across single-pole

connector 60 in the tailgate, at the left-hand
rear light cluster)

2-D, 4-D

14 Rear lights

27 Direction indicator lamps, left-hand
28 Direction indicator lamps, right-hand
30 Brake lamps

32 Reversing lamps

33 Rear fog lights

Saab 900

Page 24

OT C—O

34 Earth connections

Earthing point 65

833 SV 05 853. 5V 3.5 60 S¥V_0.5 208D

852 Sv 0.5 ey 852 Sv OS Ane SV.0.5 208P

824 SV_1.0 3 306
122 SV 05
804 SV _0.75
pa or ke 307
122 Sv O05 )
a0B SV 0.75
pn ae Saale

SV 0.75

122 “|
817 5V 05
50K Sv 0.75 ps0ee 4
1 SV.075 >
83) SV O05 rt 4
SV 0.75 308F

B19 SV 25 874 3110 i

829 SV 2.5 B74 311P

of Balen 54 2P
th 65

Earthing point 93

148 Sv 05 13, 118 (LHS)
1484 SV 05 13 ey A
27 (LHF)
597 Sv 05 2} 26 (US, CA, JP, ME, FE, AU)
148A SV_0.5 27 (LHF) '
234 (LHS)
1488 SV 0.5 119 (LHS)
648A SV 0.75 123
S19) 145 (116, 116A) i
393 SV1.5 Sa

les, ie. 16a, Ta,
TSA, 116, TIGA}

392 SV 0.5

391 BR OS |
a |
| “a = 146 (M87:116, 116)
oe 177 (18, TBA, T16, T16d)

177 93

Saab 900

Page 25

Earth connections 35

Components connected

Earthing point 65 is located under the back seat, in
the centre. The components for the passive seat
belts are connected to this earthing point.

208D Door lock, reed switch, driver's door

208P Door lock, reed switch, co-driver's door

306 Logic box for passive seat belts

307D Belt reel for passive seat belts, driver’s side

307P Belt reel for passive seat belts, co-driver’s
side

308D Motor with limit switches for passive seat
belts, driver's side

308P Motor with limit switches for passive seat
belts, (co-driver’s side)

311D Motor relay for passive seat belts, driver's
side

311P Motor relay for passive seat belts, co-
driver's side

312D Motor relay for passive seat belts, driver's
side

312P Motor relay for passive seat belts, co-
driver's side

Earthing point 93 is located at the left-hand wheel
housing, beside the amplifier for the electronic igni-
tion system.

The following components are connected to this
earthing point. Some of the components are only
fitted to cars of certain versions or for certain mar-

kets.

Connections marked with "A" apply to cars without
integrated bumpers.

13
26
27
118
119
145
146
177
234

Parking lights, LHS

Time-delay relay for radiator fan
Direction indicator lamp, LHF

Corner lamp, LHS

Side reversing lamp, LHS

EZK test socket

Amplifier for electronic ignition system
Control unit for APC system

Side marker lights, LHS

Page 26

$ gee

36 Earth connections

Earthing point 117

43 (M87)

168 SV 0.75 | 53

141 SV 1.0 64
254
121
141 SV LO eo 64
59 A )
1416 $v 1.0 Se la
232 SV _0.75 2.82 (US, CA, JP, ME)
(18, T8A, T16, T16d)
556 Sv 0.5 2.151 | (IBA:US, CA) )
, (116\;US, CA, JP, AU)
ASBA SV 15

&
1s
Safe 183

456 SV 55 456K SV_1.5 j 189 =

456C SV 1.5

456E SV 15

ts
sser| p90
sv 1.5L8

4566 SV 15 _
510 SV 1.0 3 175
501 152A 501 7 501 57 ‘
SV 1.0 zed Sv 10 ey BR 1.0 eso.’ 183 (M88: LHD)
592 SV 2.5 al
eT Ga

98

341 SV 15
343 SV_0.75 (MBB) es
267
342 SV 1.5 (Mas)
ra

67? SV 0.75 288 (US, CA, JP)

122
Sa 289 (US, CA, JP)
682 SV/GR 0.75 0 343 M87 (CAB: US)
M88 (CAB-US, CA)
177 117
Saab 900

Page 27

Earth connections 37

Components connected

On the 1987 model, earthing point 117 is located on
the handbrake lever.

On the 1988 model, earthing point 117 is located
between the ignition switch and the handbrake lever,

The front seat must be removed before access can be
gained to the earthing point.

The following components are connected to this
earthing point (the handbrake switch mounting
screw). Some of the components are only fitted to
cars of certain versions or for certain markets.

Connections marked with "A" apply to non-adjust-
able electrically-heated front seats.

43 Handbrake switch

53 Interior lighting switch

57 3-pole connector

64 Heating pad with thermostat (across 2-pole
connector 59 under the corresponding front
seat)

82 Seat belt/ignition switch warning relay

121 Seat switch for the heating pad (across
2-pole connector 59, under the right-hand
front seat)

151 Time-delay relay for the interior lighting
(across 4-pole connector 123 under the
back seat, to the left beside the relay)

152A 29-pole white connector

162 Switch for the driver's door electric window
regulator

163 Switch for the co-driver's door electric win-
dow regulator

175 Electronic unit for the central locking sys-
tem

181 Switch for the electrically operated sunroof

183

189
190
191

252
254

267

289
313

Control unit for the central locking system,
RH drive cars (across the 29-pole white con-
nector in the electrical distribution box and
3-pole connectors 57R in the right-hand
front door and forward of the right-hand
A-pillar, beside the upper hinge)

Switch for the rear-door electric window
regulators

Switch for the left-hand rear electric window
regulator

Switch for the right-hand rear electric win-
dow regulator

Rheostat for the driver's seat heating pad
Temperature sensor for the driver's seat
heating pad

Radio connections

Burglar alarm switch

Burglar alarm connector

Burglar alarm relay (CAB)

Saab 900

Page 28

SLL

38 Earth connections

Negative distribution terminal
3.5V 25 7
13 SV 6.5 85 21
4
v8L_31 447 (87)
90 SV 15 3 62
281 SV 0,75 2 73 |
&t Sv 0.75 B9
62 SV 0.75 90
1 $v 0.75 1104 (18,78: ME,FE) |
410 SV 0.5 2.106 M88 (I8A:SE, EU)
410 SV. OS wu 106
__ #104 | ag (TBA: SE, EU)
OSL 31438 |
212 SV O5 31/85 113
3%6
SV 0.5 Ug
263
Sv OS
= 270 (MAN: US)
410
Sv 0.5] 31102 (18, 18d, T8, TBA)
oe (107 1164,T16A:US,CA) p
sv 05 3156
T1534
Vv OL
$V 0.5 BG 155
314 SV 0.75 $33 314 SV 0.75 123 BR 126
6R
oa M88: US,CA
854 SV 05 To
rhise

Saab 900

Page 29

Earth connections 39

a Components connected

Distribution terminal 158 consists of a ring of flat
pins and is connected to earthing point 7 on the
radiator cross-member by means of cable 3 SV.

The terminal is located on the underside of the elec-
trical distribution box. The following components are
connected to the terminal. Some of the components
listed below are fitted only to cars of certain versions
or for certain markets.

7

21
38
42
62
e 73
89
90

104
106

7) 126

138

147
156
183

207
259

Earthing point on the radiator cross-mem-
ber

Ignition switch relay

Recirculation valve

Brake warning switch

Windscreen wiper motor

Timing service instrument socket

Side direction indicator, left-hand

Side direction indicator, right-hand

Hot start relay

Time-delay relay

Motor for the left-hand electrically operated
rear-view mirror (across 4-pole connectors
123 in the engine compartment at the left-
hand door upper hinge and in the left-hand
front door)

Engine speed relay (Turbo with manual gear-
box only)

Ignition pulse amplifier

Relay for the AC compressor

Control unit for the driver's central door lock
(across 3-pole connectors 57 in the engine
compartment at the left-hand door upper
hinge and in the left-hand front door)
Electrically-heated rear-view mirrors
Reverse-current protection relay (GB)

Cars with 8-valve engine

8
102
104
113
155
270-

Lighting relay

Fuel pump relay

Hot start relay

Relay for the electrically heated rear window
Relay for the AC radiator fan

Shift-up indication relay

Cars with 16-valve engine

8
107

113
155
270

Lighting relay

Relay for extra fog lamps (US, CA). (N.B.
Relay 107 is not earthed at distribution ter-
minal 158. Only the other terminals in this
relay position are used)

Relay for the electrically heated rear window
Relay for the AC radiator fan

Shift-up indication relay

Saab 900

Page 30

40

Earth connections

Earthing point

201

18, T8 IBA, TBA
786 Sv O73 195 iG SY OFS 1 95
268 $v 0.75 2 9¢ 268 sv O7> 296
#99 SV 05 99
352 BA 0.75 Pa |
SSLSVAVT 0.75 St 1 cist
408 Sv Os Zz 203
$35. 5V 075 949 335 5¥ 0.75 212 (AUT: US)
(AUT: ME.FE) Stt_sv o7s eee ton MBB (I8A)
477 201 477 201
M87:116
ze Sv 0.73
451 SV O75
4014 $¥ 95

551 Sv/vI_ 29 1.2001

534 Sv 15 a |
eee |

553 S¥_O75 2202

555 SV/VI_O7S 2203

552 Sy 0.75 +205

i - 201
M87:1164
401A SV 0.5 173 {AC)

_d
=|
|
| |
j |
J S547a Sv OF:
ig ee
553 Sv O75 2202
555 Sv/VT 0.75 2203
352 Sv 0.75 *~205
651 Sv 0.75 261 (MAN: US)
5 $v 0.75 271

th 201

T16 T16A
Lite sy 075 tgs AA SY 05 173 (AC)
pene O28 430 (ME, FE) 566 Sv oO} ocr |
PALSY 07S 449 (ac) <6 1 |
[soa v.03 473 (ac) ey di ae
oF a i. -+ 22 Sv /vT 25 25 |
POTS a ae 200} S\4 SV 15 "
Lsssvitzs I. |
$34 $¥ 15 n | |
ee |
rl
T0752

ee ented ine 252 5v 979 2 999

555 Sv /¥T 9.25 z 203

7 201 552 Sv O75 s 205

po! $V 075 __ 261 (MAN: US)
S71 $v or e8, cas 271
477 201
| 20s sv 07s
+r $¥ O75

| __s0ta $v 9.9

S49A SV O75

5
551 $v /Vt_ 25 rs 200]
534 Sv 15 —" ‘id
553 $v O75 £202
555 Sv/vt 075 £203
552 Sv 0.25 +205
648 Sv 45 2320
177 201
M88:1164
40ta S¥ _O5 173 (AC)

|
|_ S51 Sv /vt 2.5 —iy |
534 SV 15 —Iis I
S47 Sv 075 | I
57 ! 200!
322 L-4
$53 Sv O75 4202
|__555_Sv/vT 0.75 2203
392 SV 0.75 +205
63) SV 0.75 261 (MAN: US)
571 sv 0.75 271
| 648 Sv 15 £320

th 201

Saab 900